IFTLE 141 100GB Wide IO memory; AGC Glass Interposers; Nvidia talks stacked memory

By Garrou
 2013 ISSCC

At the 2013 IEEE ISSCC researchers from Kobe Univ and the ASET group (Assoc. of Super Advanced Electronic Technologies) presented their work on "A 100 GB/s Wide IO with 4096b TSVs through an active silicon interposer with in place waveform capturing."

As shown in the figure below their work constitutes a major jump in both bandwidth and energy consumption from other published work.



The system design is shown below. The wide IO data bus is capable of 100 GB/s sync bidirectional data transfer at 200 MHz. By putting waveform capture on the active silicon interposer (ASIP), they were able to monitor signal and power integrity within the stack. The silicon interposer provided horizontal and vertical routing for the TSV and microbumps.



Further specifications are given in the chart below.



Asahi Glass enters the Glass Interposer Market
Triton then will apply its proprietary technology to fill the high-aspect-ratio via holes with a copper paste that has the same coefficient of thermal expansion as glass.
At Nvidia's annual Graphics Technology Conference last week they announced the Volta, scheduled for release in 2015, will use stacked memories. They see the modules built on  2.5-D interposers since graphics chips generate too much heat to be stacked vertically with memories in a 3D stack.
At the recent IMAPS Device Packaging Conference in Scottsdale, AZ, the big news was that Asahi Glass (AGC) and nMode Solutions had invested $2.1 million to found Triton Micro Technologies to develop glass based 2.5D Interposers. The new company will be headquartered in Tucson AZ with a manufacturing facility planned in CA.

They will manufacture glass interposers using AGC’s EN-A1 alkali-free boro-aluminosilicate glass which has low CTE and thermal expansion properties matched to silicon. EN-A1 reportedly has refractive properties which allow for a low taper when laser drilled, providing for precise pitch control and hole size. EN-A1 has a highly polished surface and can readily accept either thin-film or thick-film metallization directly on the glass without the need for an adhesion layer. Surface roughness of 10 Å or less is typical.
Triton CTO Steve Annas indicated that they are ready for prototyping now.

Nvidia talks GPU + Memory Stacks
In an interview with EE Times [link] Nvidia Chief Scientist Bill Dally reports that the difference between 28 and 20 nm nodes is about 20 to 25 percent "Therefore, process doesn't matter that much anymore. If Nvidia is clever about architecture and circuit design, then can make up for the fact that Nvidia has competitors [Intel] that are a node ahead."    He sees chip stacking as an alternative to moving to the next semiconductor node "at a time when process technology is providing less bang for the buck."
For all the latest in 3DIC and advanced packaging, stay linked to IFTLE...




PhilG100x100

Dr. Phil Garrou gives his insight into leading edge developments in 3-D integration and advanced packaging, reporting the latest technical goings on from conferences, conversations, and more.

Previous Posts

IFTLE 153 IMAPS DPC part 3 Leti, Dow, STATSChipPAC

Wed Jul 03 16:25:00 CDT 2013

IFTLE 152 2013 IMAPS Device Packaging Conference part 2

Sat Jun 22 16:04:00 CDT 2013

IFTLE 151 2013 IMAPS Device Packaging Conf part 1 - Amkor

Sun Jun 16 11:30:00 CDT 2013

IFTLE 150 ICEP Osaka part 1

Mon Jun 10 10:22:00 CDT 2013

IFTLE 149 2013 ECTC part 1

Tue Jun 04 09:45:00 CDT 2013

IFTLE 148 The Future of Packaging: A Look From 50,000 Feet

Sat May 25 11:36:00 CDT 2013

IFTLE 147 IME Updates 2.5D; Qualcomm Updates 2.5 / 3DIC at ICEP

Mon May 13 10:16:00 CDT 2013

IFTLE 146 TSMC Apple Rumors; Gartner OSAT Mkt Numbers; Novati

Sat May 04 12:01:00 CDT 2013

IFTLE 145 GPU Roadmap, IEEE 3DIC back in SF; ConFab 2013 Pkging

Sun Apr 28 15:23:00 CDT 2013

IFTLE 144 Personnel Changes in Taiwan; Glass Usage in WLP

Sun Apr 21 10:29:00 CDT 2013

IFTLE 143 HMC status; Pkging Materials $$ now Exceed Wafer Fab Materials

Sat Apr 13 17:15:00 CDT 2013

IFTLE 142 GlobalFoundries 2.5 / 3D at 20nm; Intel Haswell GT3; UMC / SCP Prototype Details

Tue Apr 09 16:59:00 CDT 2013

IFTLE 141 100GB Wide IO memory; AGC Glass Interposers; Nvidia talks stacked memory

Sun Mar 31 12:17:00 CDT 2013

IFTLE 140 Important Apple Rumors; Xilinx not Deserting 2.5D; Book to Bill Improving

Sun Mar 24 15:20:00 CDT 2013

IFTLE 139 More on Apple A7 processor Production Rumors ; DARPAs ICECool part 2 – Applications

Sun Mar 17 11:54:00 CDT 2013

© 2013. PennWell Corporation. All Rights Reserved. PRIVACY POLICY | TERMS AND CONDITIONS